Are there open safety recalls?
1 open
Ask the seller for proof each was fixed. Repairs are free — and there’s also an open investigation.
FREE VEHICLE RESEARCH
The 2012 Hyundai Santa Fe has 1 NHTSA safety recall on file, 353 owner complaints, and gets about 23 mpg combined. Here's the full free record from NHTSA and the EPA.
FREE PUBLIC RECORD · U.S. GOVERNMENT DATA
2012 Hyundai Santa Fe
- Engine 4-cyl 2.4L
- Drive Front-Wheel Drive
- Fuel Regular
- Body Sport Utility Vehicle - 2WD
Should you worry?
Look closer
Something in the public record needs a closer look before you buy.
What do owners report?
7 injuries reported
7 of 353 reports (~2%). On a high-volume model that alone isn’t unusual — look for patterns below.
How did it score in crash tests?
3 out of 5 stars
5 is best. This is a middling overall score.
Open recalls · nearby years
Same make and model. This car is the 2012.
- 20103recalls
- 20113recalls
- 2012 · this car1recall
- 20133recalls
Based on free U.S. government safety data · checked August 23, 2026.
SAFETY
Will it protect people in a crash?
These are government crash-test scores. 5 stars is best. They rate this year and model, not your exact car.
- Overall
- 3 / 5 stars
- Frontal
- 4 / 5 stars
- Side
- 2 / 5 stars
- Side pole
- 5 / 5 stars
- Rollover
- 4 / 5 stars
Factory safety & driver-assist equipment
- Stability control
- Standard
Tested as: 2012 Hyundai Santa Fe SUV AWD · 2 versions tested
Open safety recalls
1 openA recall means the manufacturer must fix a safety problem for free at a dealer. Ask the seller for proof the work was done.
-
Engine
01/12/2020
Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Veloster, 2012 Santa Fe, 2011-2013 Sonata Hybrid, and 2016 Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which over time can result in engine damage.
How they fix it: Hyundai will notify owners, and dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System (KSDS). Repairs will be performed free of charge. The recall began March 31, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 198.
The government also has an open investigation on this model. Look it up on nhtsa.gov before you buy.
From NHTSA (U.S. safety agency) · checked August 23, 2026.
OWNERS
What problems do owners report?
People file these with the government when something goes wrong. They show patterns, not a diagnosis of any one car for sale.
Owner reports · nearby years
Same make and model. This car is the 2012.
- 2010258reports
- 2011181reports
- 2012 · this car353reports
- 2013605reports
353 owner reports on file
25 crash mentions 17 fire mentions 7 injury mentions
Parts mentioned most often. Longer bar = more reports. Counts are out of 353 total reports.
- ENGINE 177 of 353
On June 16, 2025, I dropped my 2012 Hyundai Santa Fe GLS (VIN: [XXX]) off at Larry H. Miller Southwest in Albuquerque, NM for NHTSA safety recall #20V746000 (Theta II engine connecting rod bearing failure). It has now been over one week wit
- ELECTRICAL SYSTEM 35 of 353
The contact purchased a 2012 Hyundai Santa Fe. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mi
- VEHICLE SPEED CONTROL 27 of 353
STOPPED AT A RED LIGHT. STEPPED ON GAS TO MOVE AND THE ENGINE REVVED UP AND IT JUST TOOK OFF. HAD TO USE BOTH FEET ON BRAKE PEDAL TO STOP THE CAR. GOING ABOUT 1 MPH AFTER THE LIGHT TURNED GREEN. THE ENGINE ACCELERATED AND WOULDN'T STOP.
- POWER TRAIN 23 of 353
MY 2012 HYUNDI SANTA FE STALLED ON ME AS I WAS APPROACHING A TRAFFIC LIGHT 3 WEEKS AGO.. LAST WEEK MY CHECK ENGINE OIL LIGHT CAME ON MY DASHBOARD. I TOOK IT TO A CERTIFIED MECHANIC AND HE SAID THE PROBLEM WAS A REAR CRANKSHAFT MAIN BEARING
- STEERING 16 of 353
ALL THREE LIGHTS ABS, ESC, AND DBC ON DASH CAME ON SAME TIME AFTER REPLACING DRIVERS SIDE HEAD LIGHT BULB. WHEEL SPEED SENSOR AND TRACTION CONTROL IMPACTING THE DRIVEABILITY.
- SUSPENSION 14 of 353
Rear subframe suddenly collapsed and broke due to extreme corrosion. Incident occurred while driving, allowing rear wheel to turn out causing loss of control. Luckily I was traveling at a low rate of speed and nobody was hurt. Found rear
Bars are sized relative to the most-mentioned part on this list, not to 100% of all cars.
From NHTSA owner complaints · checked August 23, 2026. Anyone can file a report; they are not verified repairs.
FUEL COST
What does it cost to drive?
EPA estimates for this year and model. Your real cost depends on gas prices, how you drive, and how far you go.
Sold in 2 versions
They range from 22 to 23 mpg combined. Figures below are the base version. Pick yours to see its own numbers.
Combined MPG · nearby years
Same make and model. This car is the 2012.
- 201023mpg
- 201122mpg
- 2012 · this car23mpg
- 201321mpg
$2,650
estimated fuel cost per year if you drive about 15,000 miles
Miles per gallon. Higher is cheaper to drive.
City driving 20 mpg
Highway driving 27 mpg
Combined (typical mix) 23 mpg
Over 5 years, compared to an average new car
This model is estimated to cost about $2,250 more on fuel.
Spends more Saves more
From EPA fueleconomy.gov · checked August 23, 2026.
HOW IT WAS BUILT
Factory details
What’s on the build record for this VIN or model.
Engine
4-cyl 2.4L
Drivetrain
Front-Wheel Drive
Transmission
Automatic 6-spd
Fuel
Regular
See all factory details (7)
- Engine
- 4-cyl 2.4L
- Cylinders
- 4
- Displacement
- 2.4 L
- Drivetrain
- Front-Wheel Drive
- Transmission
- Automatic 6-spd
- Body
- Sport Utility Vehicle - 2WD
- Fuel
- Regular
From EPA and NHTSA vehicle records · checked August 23, 2026.
What this free check does not include
We only show free U.S. government data: safety recalls, owner reports, crash tests, and fuel economy. We do not show prior accidents, flood or salvage titles, odometer rollback, insurance history, or a “should you buy” verdict on a specific listing. For that kind of check on one car for sale, use the VINly app.
BEFORE YOU BUY
What to check on this car
Confirm the recall was fixed
This model has 1 open NHTSA recall (including the engine). Recall repairs are free at the dealer, so ask the seller for proof the remedy was performed, or verify by VIN at nhtsa.gov before you buy.
Have a mechanic check the engine
Owners report problems with the engine more than anything else on this model. Call it out specifically during a pre-purchase inspection.
Watch for a pending investigation
NHTSA has an open investigation covering this model. A recall can follow an investigation, so check nhtsa.gov for the latest before you commit.
-
Test-drive the basics
Cold start, full-lock steering both ways, firm brakes with no pulsing, smooth shifts, and every electronic feature. Warning lights should come on at key-on, then go out.
-
Check the title and the VIN
Confirm the title status in hand matches the listing, and that the VIN matches across the dash, door jamb, and title. VINly does not show ownership or accident history, for that, run a paid report like Carfax.
-
Ask the seller the right questions
Why they are selling, any service records, accident or panel-repaint history, how many owners, and whether any open recalls were completed.
See the full used-car inspection checklist. None of this replaces a hands-on inspection by a mechanic.
FOR SALE NEAR YOU
2012 Hyundai Santa Fe listings
Quick answers
What is recalled on the 2012 Hyundai Santa Fe? +
NHTSA lists 1 safety recall for the 2012 Hyundai Santa Fe, including the engine. See the full list above, and confirm by VIN at nhtsa.gov.
What gas mileage does the 2012 Hyundai Santa Fe get? +
The EPA rates the 2012 Hyundai Santa Fe at 23 mpg combined (20 city / 27 highway), about $2,650 a year in fuel.
How safe is the 2012 Hyundai Santa Fe? +
NHTSA's NCAP program gives the 2012 Hyundai Santa Fe 3 out of 5 stars overall, with 4 stars for rollover resistance.
What do owners complain about on the 2012 Hyundai Santa Fe? +
Owners have filed 353 complaints with NHTSA for the 2012 Hyundai Santa Fe, including 25 involving a crash. The most-reported area is engine.
MORE HYUNDAI RESEARCH
FREE IN THE APP
Comparing a few cars? Save the 2012 Hyundai Santa Fe and line it up against the others in the app.
No account. Saving and comparing cars is free.
FREE ON iOS
Shopping for a 2012 Hyundai Santa Fe?
Scan any VIN with your camera, save cars you’re comparing, and browse listings near you. All free. Same NHTSA and EPA data you see here, plus a camera-first VIN scanner.