Are there open safety recalls?
3 open
Ask the seller for proof each was fixed. Repairs are free — and there’s also an open investigation.
FREE VEHICLE RESEARCH
The 2016 Hyundai Santa Fe has 3 NHTSA safety recalls on file, 235 owner complaints, and gets about 22 mpg combined. Here's the full free record from NHTSA and the EPA.
FREE PUBLIC RECORD · U.S. GOVERNMENT DATA
2016 Hyundai Santa Fe
- Engine 4-cyl 2L
- Drive Front-Wheel Drive
- Fuel Regular
- Body Small Sport Utility Vehicle 2WD
Should you worry?
Look closer
Something in the public record needs a closer look before you buy.
What do owners report?
6 injuries reported
6 of 235 reports (~3%). On a high-volume model that alone isn’t unusual — look for patterns below.
How did it score in crash tests?
Not tested
No official 5-star crash-test score for this year and model.
Open recalls · nearby years
Same make and model. This car is the 2016.
- 20143recalls
- 20152recalls
- 2016 · this car3recalls
- 20176recalls
Based on free U.S. government safety data · checked August 23, 2026.
SAFETY
Will it protect people in a crash?
These are government crash-test scores. 5 stars is best. They rate this year and model, not your exact car.
- Overall
- Not rated
- Frontal
- Not rated
- Side
- Not rated
- Rollover
- Not rated
Factory safety & driver-assist equipment
- Stability control
- Standard
Tested as: 2016 Hyundai Santa Fe SUV FWD · 2 versions tested
Open safety recalls
3 openA recall means the manufacturer must fix a safety problem for free at a dealer. Ask the seller for proof the work was done.
-
Latches/Locks/Linkages
05/06/2017
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
How they fix it: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.
-
Seat Belts
10/03/2016
Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
How they fix it: Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.
-
Service Brakes, Hydraulic
03/02/2022
Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.
How they fix it: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.
The government also has an open investigation on this model. Look it up on nhtsa.gov before you buy.
From NHTSA (U.S. safety agency) · checked August 23, 2026.
OWNERS
What problems do owners report?
People file these with the government when something goes wrong. They show patterns, not a diagnosis of any one car for sale.
Owner reports · nearby years
Same make and model. This car is the 2016.
- 2014494reports
- 2015254reports
- 2016 · this car235reports
- 2017951reports
235 owner reports on file
6 crash mentions 2 fire mentions 6 injury mentions
Parts mentioned most often. Longer bar = more reports. Counts are out of 235 total reports.
- ENGINE 130 of 235
WHAT FAILED: The engine — the 3.3L Lambda II GDI V6 (engine family GHYXV03.31XE per the federal emissions label) — failed catastrophically: a connecting rod penetrated the engine block. The failed engine IS available for inspection on reque
- UNKNOWN OR OTHER 20 of 235
The motor began to making a knocking noise and started smoking like a fire was starting. We immediately turned off the vehicle preventing from a full fledge fire. We had children in the car as well which posed a safety concern for them. We
- POWER TRAIN 19 of 235
Hard Shift occurs between gear 1 and gear 2. The hard shift lurches the entire car. It occurs on both upshift and downshift. The hard shift occurs on cold starts. The problem goes away when you turn the vehicle off and then back on. There a
- SERVICE BRAKES 12 of 235
The contact owns a 2016 Hyundai Santa Fe. The contact stated while driving at an undisclosed speed, the contact stated that the brake pedal was inoperable. The contact stated that the vehicle vibrated while depressing the brake pedal. There
- ELECTRICAL SYSTEM 9 of 235
Abs system is randomly locking up calipers causing a dangerous speed wobble. Dealership can't re create so won't diagnose. Have had to replace all brake calipers and components were near new but ruined because of abs applying brakes when un
- AIR BAGS 7 of 235
Someone backed out of a parking lot and I crashed into their rear passenger side. Other party at fault but my air bags for 2016 Hyundai Santa Fe Sport did not deploy.
Bars are sized relative to the most-mentioned part on this list, not to 100% of all cars.
From NHTSA owner complaints · checked August 23, 2026. Anyone can file a report; they are not verified repairs.
FUEL COST
What does it cost to drive?
EPA estimates for this year and model. Your real cost depends on gas prices, how you drive, and how far you go.
Showing
Figures below are for the Sport Ultimate FWD version.
Combined MPG · nearby years
Same make and model. This car is the 2016.
- 201421mpg
- 201520mpg
- 2016 · this car22mpg
- 201720mpg
$2,800
estimated fuel cost per year if you drive about 15,000 miles
Miles per gallon. Higher is cheaper to drive.
City driving 19 mpg
Highway driving 26 mpg
Combined (typical mix) 22 mpg
Over 5 years, compared to an average new car
This model is estimated to cost about $3,000 more on fuel.
Spends more Saves more
From EPA fueleconomy.gov · checked August 23, 2026.
HOW IT WAS BUILT
Factory details
What’s on the build record for this VIN or model.
Engine
4-cyl 2L
Drivetrain
Front-Wheel Drive
Transmission
Automatic (S6)
Fuel
Regular
See all factory details (7)
- Engine
- 4-cyl 2L
- Cylinders
- 4
- Displacement
- 2 L
- Drivetrain
- Front-Wheel Drive
- Transmission
- Automatic (S6)
- Body
- Small Sport Utility Vehicle 2WD
- Fuel
- Regular
From EPA and NHTSA vehicle records · checked August 23, 2026.
What this free check does not include
We only show free U.S. government data: safety recalls, owner reports, crash tests, and fuel economy. We do not show prior accidents, flood or salvage titles, odometer rollback, insurance history, or a “should you buy” verdict on a specific listing. For that kind of check on one car for sale, use the VINly app.
BEFORE YOU BUY
What to check on this car
Confirm the recalls were fixed
This model has 3 open NHTSA recalls (including the latches/locks/linkages). Recall repairs are free at the dealer, so ask the seller for proof the remedy was performed, or verify by VIN at nhtsa.gov before you buy.
Have a mechanic check the engine
Owners report problems with the engine more than anything else on this model. Call it out specifically during a pre-purchase inspection.
Watch for a pending investigation
NHTSA has an open investigation covering this model. A recall can follow an investigation, so check nhtsa.gov for the latest before you commit.
-
Test-drive the basics
Cold start, full-lock steering both ways, firm brakes with no pulsing, smooth shifts, and every electronic feature. Warning lights should come on at key-on, then go out.
-
Check the title and the VIN
Confirm the title status in hand matches the listing, and that the VIN matches across the dash, door jamb, and title. VINly does not show ownership or accident history, for that, run a paid report like Carfax.
-
Ask the seller the right questions
Why they are selling, any service records, accident or panel-repaint history, how many owners, and whether any open recalls were completed.
See the full used-car inspection checklist. None of this replaces a hands-on inspection by a mechanic.
FOR SALE NEAR YOU
2016 Hyundai Santa Fe listings
Quick answers
What is recalled on the 2016 Hyundai Santa Fe? +
NHTSA lists 3 safety recalls for the 2016 Hyundai Santa Fe, including the latches/locks/linkages. See the full list above, and confirm by VIN at nhtsa.gov.
What gas mileage does the 2016 Hyundai Santa Fe get? +
The EPA rates the 2016 Hyundai Santa Fe at 22 mpg combined (19 city / 26 highway), about $2,800 a year in fuel.
What do owners complain about on the 2016 Hyundai Santa Fe? +
Owners have filed 235 complaints with NHTSA for the 2016 Hyundai Santa Fe, including 6 involving a crash. The most-reported area is engine.
MORE HYUNDAI RESEARCH
FREE IN THE APP
Comparing a few cars? Save the 2016 Hyundai Santa Fe and line it up against the others in the app.
No account. Saving and comparing cars is free.
FREE ON iOS
Shopping for a 2016 Hyundai Santa Fe?
Scan any VIN with your camera, save cars you’re comparing, and browse listings near you. All free. Same NHTSA and EPA data you see here, plus a camera-first VIN scanner.