FREE VEHICLE RESEARCH
2021 Hyundai Santa Fe AWD
The 2021 Hyundai Santa Fe AWD has 7 NHTSA safety recalls on file, 160 owner complaints, and gets about 24 mpg combined. Here's the full free record from NHTSA and the EPA.
SPECS
2021 Hyundai Santa Fe AWD at a glance
- Engine
- 4-cyl 2.5L
- Cylinders
- 4
- Displacement
- 2.5 L
- Drivetrain
- All-Wheel Drive
- Transmission
- Automatic (AM-S8)
- Body
- Small Sport Utility Vehicle 4WD
- Fuel
- Regular
Source: EPA / NHTSA vPIC, as of July 9, 2026.
SAFETY RECALLS · NHTSA
7 openFuel System, Gasoline
09/07/2021
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe and Sonata vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail.
Remedy: Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 207.
Visibility
28/12/2021
Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Santa Fe, 2021 Sonata, and Elantra vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash.
Remedy: Dealers will remove and reinstall the front windshield panel, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 216.
Air Bags
17/03/2021
Hyundai Motor America (Hyundai) is recalling certain 2021 Santa Fe vehicles. The Occupant Detection System (ODS) module may not deactivate the air bag upon detection of a child restraint system in the front passenger seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Remedy: Hyundai will notify owners, and dealers will replace the ODS module, free of charge. All affected vehicles have been remedied as of May 12, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 202.
Fuel System, Gasoline
03/05/2021
Hyundai Motor America (Hyundai) is recalling certain 2021 Santa Fe vehicles equipped with 2.5-litre Turbo engines. The fuel pipe connecting the high pressure fuel pump to the fuel rail may not have been tightened properly.
Remedy: Dealers inspected and tightened the fuel pipe connection, free of charge. The affected vehicles have been repaired and therefore no owner notification letters will be sent. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 206.
Power Train
06/10/2022
Hyundai Motor Company (Hyundai) is recalling certain 2021-2022 Santa Fe, Sonata, Veloster N, 2022 Santa Cruz, Elantra N, and Kona N vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete loss of drive power.
Remedy: Dealers will inspect and replace the transmission, as necessary. Dealers will also update the transmission control unit software. All repairs will be performed free of charge. Owner notification letters were mailed January 10, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 236.
Trailer Hitches
17/03/2023
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Remedy: Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.
Back Over Prevention
21/11/2024
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed January 14, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 271.
NHTSA has opened one or more investigations covering this model. Recalls can follow an investigation, so check NHTSA for the latest before you buy.
Open safety recalls are free to fix at any franchised dealer. What recalls mean → Source: NHTSA recalls, as of July 9, 2026. Recalls can be issued any time, confirm by VIN at nhtsa.gov before you buy.
OWNER COMPLAINTS · NHTSA
160 filed- 50
POWER TRAIN
The contact owns a 2021 Hyundai Santa Fe. The contact stated that while driving approximately 5-30 MPH, the transmission failed to shift properly, and the vehicle lost motive power. The engine warning light was illuminated. The contact stat
- 29
UNKNOWN OR OTHER
On March 17, 2026, the sunroof of our Hyundai Sante Fe 2021 exploded. The driver and two passengers were not hurt because the sunroof was closed and the liner in place when the explosion took place. The incident occurred on an open country
- 23
ELECTRICAL SYSTEM
The rearview backup camera system malfunctioned. The camera was replaced under a safety recall on my 2021 Hyundai Santa Fe. Within four days of the recall repair, the camera continued to fail intermittently, displaying a blank/black screen
- 15
ENGINE
My 2021 Hyundai Santa Fe (VIN [XXX] ) is experiencing severe engine instability, including rough idling, hesitation upon acceleration, and intermittent stalling. These symptoms align with TSB 26-FL-001H regarding defective GDI fuel injector
- 7
VISIBILITY
The contact owns a 2021 Hyundai Santa Fe. The contact stated that while the vehicle was parked and occupied, a bystander noticed that the glass partition had shattered without impact. The dealer was contacted. The vehicle was taken to the d
- 6
VISIBILITY/WIPER
My 2021 Hyundai Santa Fe (VIN starting with 5NM) began experiencing a significant failure of the air conditioning system during its third year of ownership. The vehicle developed a persistent refrigerant leak that now requires annual rechar
Problems owners reported to the government, useful for spotting patterns, not proof any one car has them. What complaints mean → Source: NHTSA complaints, as of July 9, 2026. Owner-submitted reports, not verified diagnoses.
CRASH-TEST RATINGS · NHTSA NCAP
- Overall
- ★★★★★
- Frontal
- ★★★★★
- Side
- ★★★★★
- Rollover
- ★★★★☆
Government crash tests of this model; not every trim or year is tested. Source: NHTSA NCAP, as of July 9, 2026.
FUEL & RUNNING COST · U.S. EPA
- Combined
- 24 mpg
- City / Hwy
- 21 / 28
- Est. fuel / yr
- $2,600
- CO₂ / mi
- 375 g
EPA lab estimates; real mpg varies by how you drive. Source: EPA fueleconomy.gov, as of July 9, 2026. Annual cost assumes 15,000 mi/yr at EPA's reference price.
All figures above come from free U.S. government sources: NHTSA (recalls, complaints, investigations, crash tests) and the EPA (fuel economy and specs). We don't show market price, insurance cost, or proprietary reliability scores, because there's no free, reliable public source for them. For a verdict on a specific listing, with a fair-offer number and what to ask the seller, that's the VINly app.
BEFORE YOU BUY
What to check on this car
Confirm the recalls were fixed
This model has 7 open NHTSA recalls (including the fuel system, gasoline). Recall repairs are free at the dealer, so ask the seller for proof the remedy was performed, or verify by VIN at nhtsa.gov before you buy.
Have a mechanic check the power train
Owners report problems with the power train more than anything else on this model. Call it out specifically during a pre-purchase inspection.
Watch for a pending investigation
NHTSA has an open investigation covering this model. A recall can follow an investigation, so check nhtsa.gov for the latest before you commit.
-
Test-drive the basics
Cold start, full-lock steering both ways, firm brakes with no pulsing, smooth shifts, and every electronic feature. Warning lights should come on at key-on, then go out.
-
Check the title and the VIN
Confirm the title status in hand matches the listing, and that the VIN matches across the dash, door jamb, and title. VINly does not show ownership or accident history, for that, run a paid report like Carfax.
-
Ask the seller the right questions
Why they are selling, any service records, accident or panel-repaint history, how many owners, and whether any open recalls were completed.
See the full used-car inspection checklist. None of this replaces a hands-on inspection by a mechanic.
Quick answers
What is recalled on the 2021 Hyundai Santa Fe AWD? +
NHTSA lists 7 safety recalls for the 2021 Hyundai Santa Fe AWD, including the fuel system, gasoline. See the full list above, and confirm by VIN at nhtsa.gov.
What gas mileage does the 2021 Hyundai Santa Fe AWD get? +
The EPA rates the 2021 Hyundai Santa Fe AWD at 24 mpg combined (21 city / 28 highway), about $2,600 a year in fuel.
How safe is the 2021 Hyundai Santa Fe AWD? +
NHTSA's NCAP program gives the 2021 Hyundai Santa Fe AWD 5 out of 5 stars overall, with 4 stars for rollover resistance.
What do owners complain about on the 2021 Hyundai Santa Fe AWD? +
Owners have filed 160 complaints with NHTSA for the 2021 Hyundai Santa Fe AWD, including 4 involving a crash. The most-reported area is power train.
MORE HYUNDAI RESEARCH
FREE IN THE APP
Comparing a few cars? Save the 2021 Hyundai Santa Fe AWD and line it up against the others in the app.
No account. Saving and comparing cars is free; the per-listing report is $3.99.
THE FULL BUYER'S REPORT · $3.99
Found a 2021 Hyundai Santa Fe AWD for sale?
The research above is free. The app takes a screenshot of one real listing and returns a verdict, a fair-offer number, the red flags specific to that car, a walk-away floor, and a message you can send the seller, word for word.